| Content
Specifications
Specifications
Dimensional drawings
Maintenance information
The importance of proper maintenance
Important precautions
Conventions and symbols used in this manual
Serial number location
Maintenance data
Tightening torques for threaded connections
Special tools
Possible malfunctions and solutions
Laying cables and wiring harnesses
Lubrication points
Maintenance
Maintenance intervals
Engine oil
Oil filter
Transmission oil
Spark plug
Valve clearance
Carburetor
Fuel filter
Fuel pickup strainer
Fuel lines
Throttle control links
Timing belt
Breather (crankcase ventilation)
Exhaust gas toxicity (Lake Constance standard)
Propeller / reverse mechanism / column
Propeller
Sterntube housing
Reverse mechanism housing
Water pump
Transmission shaft / bevel gear
Water pump body
Reverse gear case / anti-corrosion anode / water inlet strainer
Speaker cover
Exhaust manifold cover
Engine covers
Upper engine cover
Left lower engine cover
Right lower engine cover
Power system
Silencer / carburetor
Choke cable
Fuel pump / fuel filter
Fuel tank
Recoil drum starter
Neutral start cable
Recoil starter
Cover for starter
Engine removal / installation
Removing the engine
Engine installation
Flywheel / timing belt
Flywheel / coils
Timing belt / pulleys
Cylinder head / valves / oil pump
Removing the cylinder head
Oil pump
Dismantling the cylinder head
Valve seat reconditioning
Cylinder head assembly
Installing the cylinder head
Crankcase / crankshaft / piston
Thermostat / cooling jacket
Oil receiver strainer
Piston
Crankshaft / cylinder block
Oil sump / transom bracket / vertical axle housing
Oil sump
Friction adjustment lever (friction lever)
Main frame
Transom bracket
Vertical axis body
Switch mechanism
Shift lever / throttle lever
Switch lever
Switch stem
Tie rod / remote control station
Tie rod
Remote control cable
Remote control wire harness
Remote control
Rumpel
Rumpel
Tiller bracket
Throttle
Starter switch
Emergency stop switch
Electrical equipment
Starter
Starter bus (motor with 12A charging coil)
Charging wire (motor with 6A charging coil)
Neutral switch / warning switch
Ignition controller
Bracket for connectors
Ignition coil
Regulator / rectifier
Wiring diagrams
Index |
Copyright (c) 2008 disc.allsave.info.